LONG parts quote list.

[E.J.]

So, it's been a while but I've been busy hunting down some parts. Now I'm ready to start installing but I need a few more things.

Let me get the basics out of the way, my car is a '91 N/A with T-Tops and power steering, cruise control, etc.

(side note: seems the general consensus is to upgrade some parts to +93 spec, but I personally want all '91 spec parts. Thank you.)

I want to change my timing belt and since I'm doing it that I might as well change out all I can since engine would be out.

So after searching I found other people asked for the same thing but I'm not sure if these part numbers are for the Turbo or N/A, so I would appreciate your help .

9364-70830-83 - Alternator belt

16100-79135-83 - Water pump assy.
15100-74060 - Oil pump assy.
15197-03040 - Oil pump to block gasket
13568-09041 - Timing belt

90507-17003 - Timing belt tensioner spring
13505-74011 - Idler no.1 (tensioner)
13503-63011 - Idler no.2 (fixed)
90080-31023 - Cam seal
90080-31022 - Crank seal (front)

If you do not replace the oil pump you'll also want these:
15165-70010 - Oil pump shaft seal
15188-63010 - Oil pump housing o-ring

Let me know if I need anything else please. I'd rather have everything here when I pull everything apart.

On to the next thing, I found a set of TRD springs and TRD sway bars (F/R) BNIB so those are going in too.

I've already ordered these from you,

2361-74160 - Motor mount, front (cabin)
12371-74230 - Motor mount, rear (trunk)
12362-74170 - Motor mount, RH (nose of engine)
12372-74260 - Motor mount, LH (top of tranny)
04438-20070 - CV boot kit, axle (x2)

I need to know what else I need since I want to replace everything old to new while it's all taken apart, after searching seems I need these as well.

43330-19025 - Ball joint, front (x2)
43330-39275 - Ball joint, rear (x2)
48331-17030 - Bumpstop/boot, front (x2)
48341-17020 - Bumpstop/boot, ,rear (x2)
48609-17030 - Strut mount, front (x2)
90303-22049 - Dust seal, front strut mount bearing (x2)
48750-17031 - Strut mount, rear (x2)

Again, not sure if these are the right part numbers or if the list is incomplete. Your help would be much appreciated.

Finally, would you happen to know if the discontinued TRD shocks were made by Bilstein or Tokico? Tried searching but not coming up with a definate answer.

I can't find the TRD shocks so I'm settling for one of the two, depends who made the orginal TRD shocks.

Alright, please let me know about the prices. No rush and I will be ready to make my first orders this Friday or Saturday (7/17 - 7/18).

Might as well add these in too;

TRD:

Oil cap (kanji)



Radiator cap



Oil filter



Thermostat



Air filter



Brake pads



Fuel filler cap



Sorry, I don't have Parts numbers, but I have pictures .

If you have the part numbers I'd love to have them for my personal records, Thanks in advance for your hard work.

[eckoman_pdx]

Originally Posted by E.J.

So, it's been a while but I've been busy hunting down some parts. Now I'm ready to start installing but I need a few more things.

Let me get the basics out of the way, my car is a '91 N/A with T-Tops and power steering, cruise control, etc.

(side note: seems the general consensus is to upgrade some parts to +93 spec, but I personally want all '91 spec parts. Thank you.)

I want to change my timing belt and since I'm doing it that I might as well change out all I can since engine would be out.

So after searching I found other people asked for the same thing but I'm not sure if these part numbers are for the Turbo or N/A, so I would appreciate your help .

9364-70830-83 - Alternator belt

16100-79135-83 - Water pump assy.
15100-74060 - Oil pump assy.
15197-03040 - Oil pump to block gasket
13568-09041 - Timing belt

90507-17003 - Timing belt tensioner spring
13505-74011 - Idler no.1 (tensioner)
13503-63011 - Idler no.2 (fixed)
90080-31023 - Cam seal
90080-31022 - Crank seal (front)

If you do not replace the oil pump you'll also want these:
15165-70010 - Oil pump shaft seal
15188-63010 - Oil pump housing o-ring

Let me know if I need anything else please. I'd rather have everything here when I pull everything apart.

On to the next thing, I found a set of TRD springs and TRD sway bars (F/R) BNIB so those are going in too.

I've already ordered these from you,

2361-74160 - Motor mount, front (cabin)
12371-74230 - Motor mount, rear (trunk)
12362-74170 - Motor mount, RH (nose of engine)
12372-74260 - Motor mount, LH (top of tranny)
04438-20070 - CV boot kit, axle (x2)

I need to know what else I need since I want to replace everything old to new while it's all taken apart, after searching seems I need these as well.

43330-19025 - Ball joint, front (x2)
43330-39275 - Ball joint, rear (x2)
48331-17030 - Bumpstop/boot, front (x2)
48341-17020 - Bumpstop/boot, ,rear (x2)
48609-17030 - Strut mount, front (x2)
90303-22049 - Dust seal, front strut mount bearing (x2)
48750-17031 - Strut mount, rear (x2)

Again, not sure if these are the right part numbers or if the list is incomplete. Your help would be much appreciated.

Finally, would you happen to know if the discontinued TRD shocks were made by Bilstein or Tokico? Tried searching but not coming up with a definate answer.

I can't find the TRD shocks so I'm settling for one of the two, depends who made the orginal TRD shocks.

Alright, please let me know about the prices. No rush and I will be ready to make my first orders this Friday or Saturday (7/17 - 7/18).

Might as well add these in too;

TRD:

Oil cap (kanji)

http://i22.photobucket.com/albums/b3.../TRDoilcap.jpg

Radiator cap

http://i22.photobucket.com/albums/b3.../TRDradcap.jpg

Oil filter

http://i22.photobucket.com/albums/b3...TRDoilfltr.jpg

Thermostat

http://i22.photobucket.com/albums/b3...thermostat.jpg

Air filter

http://i22.photobucket.com/albums/b3...TRDairfltr.jpg

Brake pads

http://i22.photobucket.com/albums/b3.../TRDbrkpad.jpg

Fuel filler cap

http://i22.photobucket.com/albums/b3...TRDfuelcap.jpg

Sorry, I don't have Parts numbers, but I have pictures .

If you have the part numbers I'd love to have them for my personal records, Thanks in advance for your hard work.

These should be the part numbers for all of the TRD parts you listed.

TRD Oil cap (Aluminum, Silver)
12180-SP002

TRD Radiator Cap (1.5kgf/cm2 / 21psi)
16401-SP020

TRD Radiator Cap (1.3kgf/cm2 /18.5psi)
16401-SP002

TRD Sports Oil Filter (3S-GTE)
90915-SP010

TRD Sports Thermostat (Gen 2)
16340-SP010

TRD Sports Thermostat (Gen 3)
16340-SP030

TRD Sports Air Filter (Discontinued)
17801-AE910

TRD Brake Pads (Red)
Front: 91.12-99.10
04491-SW210

Rear: 91.12-99.10
04492-SW200

TRD Fuel Filler Cap
77315-SP000

[E.J.]

Guess it was TOO long a list...

[te51levin]

Originally Posted by E.J.

Guess it was TOO long a list...

Not too long, but too long and too complicated to do quickly, and that means I have to push it to the back burner while I answer phones and take care of all the other customers who have shorter lists. I actually started working on this about two hours ago, but there's always some interruption. For example, we have a local guy who comes in every so often and tried to get us to repair his tobacco pipe with Scotch tape. I am not making this up...

Anyway, wow, nice job! Almost all of the part numbers are correct. Some of them had a digit snipped off, and some of the suspension parts you listed were '93+ parts, so I have corrected and/or changed them to zenki parts as per your request.

99364-70830-83 - $11.57 - Alternator belt, w/ power steering

16100-79135-83 - $86.66 - Water pump assy.
15100-74060 - $119.18 - Oil pump assy.
15197-03040 - $8.62 - Oil pump to block gasket
13568-09041 - $28.50 - Timing belt

90507-17003 - $2.59 - Timing belt tensioner spring
13505-74011 - $85.01 - Idler no.1 (tensioner)
13503-63011 - $49.05 - Idler no.2 (fixed)
90080-31023 - $6.72 - Cam seal
90080-31022 - $7.80 - Crank seal (front)

15165-70010 - $7.12 - Oil pump shaft seal
15188-63010 - $11.61 - Oil pump housing o-ring
43330-19025 - $32.50 - Ball joint, front (x2 = $65.00)
43330-39275 - $35.95 - Ball joint, rear (x2 = $71.90)
48331-17021 - $18.69 - Bumpstop/boot, front (x2 = $37.38)
48341-17011 - $19.75 - Bumpstop/boot, rear (x2 = $39.50)
48609-17030 - $78.07 - Strut mount, front (x2 = $156.14)
90303-22049 - $3.52 - Dust seal, front strut mount bearing (x2 = $7.04)
48750-17020 - $113.18 - Strut mount, rear (x2 = $226.36)

And as far as the TRD stuff goes, anything that is still active and carries a PTR part number is normally stocked in US warehouses. Anything else is typically a special order part from TRD Japan, which involves wait times of up to four months or sometimes even longer, *IF* they don't cancel the order on us.

PTR04-12108-02 - $46.80 - Oil cap (kanji)
PTR04-00000-01 - $31.56 - Radiator cap, 18.5 psi
PTR43-33010 - $9.30 - Oil filter, TRD USA
PTR04-00000-14 - *DISCONTINUED* - Oil filter, TRD Japan
PTR04-35050 - $68.40 - Thermostat, 160 degree
17801-AE910 - *DISCONTINUED* - TRD Air filter
TRD brake pads, front - *NOT AVAILABLE*
04492-SW200 - $130-ish - TRD Brake pads, rear, black
77315-SP000 - $38-ish - TRD Fuel Filler Cap (waiting to hear back on availability)


The quote number is 48484. Thanks EJ!

[E.J.]

Originally Posted by te51levin

The quote number is 48484. Thanks EJ!

Thank you sir.

I will call Saturday and speak to Chase I believe you said his name was.

[te51levin]

Originally Posted by E.J.

Thank you sir.

I will call Saturday and speak to Chase I believe you said his name was.

You're quite welcome! Let me know which items you will most likely want, and I will trim up the quote and figure shipping to make it as streamlined as possible.

[BrandoMKII]

I was told that TRD was discontinued. Or is that maybe just in my area?
If it isn't I would definitely get in on some of that stuff haha

[te51levin]

Originally Posted by BrandoMKII

I was told that TRD was discontinued. Or is that maybe just in my area?

It's not that simple. Toyota Racing Development, as a company, is still alive in Japan. TRD USA is also still alive. However, many of the parts that TRD Japan once offered for MR2s have been discontinued. Also, some of the TRD Japan parts that TRD USA once stocked in US warehouses for US dealers have been discotninued by TRD USA; they are no longer being stocked in US warehouses. In some cases we can still order them individually, but since that involves a four month wait, many customers are not as interested as they once were.

One note, though: many dealers will assume that there's nothing available from TRD for a car this old, and in almost every case, they're correct. We (the MR2 community) still have a few things available, and are more willing to jump through hoops and wait a long time to find out what is available and to get the things we want.

By the way, I noticed by your signature that you are looking for a few parts that you'll be better off buying new. Door handle bezels and shift boots are not expensive, and used examples are typically not worth bothering with. I can also get the stainless sill plate trim shown in your signature pic.

69277-17020-22 - $11.17 - Bezel, door handle, RH
69278-17010-22 - $11.17 - Bezel, door handle, LH
58808-17020-01 - $31.50 - Shift boot, '91-'92
67919-17010 - $34.28 - Ornament, door scuff plate (x2 = $68.56)

These are saved on quote number 48537 if you feel like ordering them!

[E.J.]

Originally Posted by te51levin

You're quite welcome! Let me know which items you will most likely want, and I will trim up the quote and figure shipping to make it as streamlined as possible.

E-mail sent to awillis@lithia.com with parts list.

Thanks for your hard work .